系統識別號 | U0002-3009201509022600 |
---|---|
DOI | 10.6846/TKU.2015.01111 |
論文名稱(中文) | 多拍翼編隊飛行節能之地面初測 |
論文名稱(英文) | Energy Saving in Flapping Formation Flight: The First Ground Test |
第三語言論文名稱 | |
校院名稱 | 淡江大學 |
系所名稱(中文) | 機械與機電工程學系碩士班 |
系所名稱(英文) | Department of Mechanical and Electro-Mechanical Engineering |
外國學位學校名稱 | |
外國學位學院名稱 | |
外國學位研究所名稱 | |
學年度 | 103 |
學期 | 2 |
出版年 | 104 |
研究生(中文) | 陳建瑋 |
研究生(英文) | Chien-Wei Chen |
學號 | 602370552 |
學位類別 | 碩士 |
語言別 | 繁體中文 |
第二語言別 | |
口試日期 | 2015-07-10 |
論文頁數 | 118頁 |
口試委員 |
指導教授
-
楊龍杰(ljyang@mail.tku.edu.tw)
委員 - 李其源(cylee@saturn.yzu.edu.tw) 委員 - 王人牧(wang@mail.ce.tku.edu.tw) |
關鍵字(中) |
拍翼機 風洞量測 編隊飛行 升推力量測 |
關鍵字(英) |
flapping micro-air-vechicle(MAV) wind tunnel test formation flight lift force and thrust force testing |
第三語言關鍵字 | |
學科別分類 | |
中文摘要 |
根據Lissaman 與 Shollenberger於1970年的Science文章,提到鳥類的編隊飛行帶來了節能的效果,因此進一步思考:假若使用仿生拍翼機進行群體飛行,是否也能得到類似的節能效果。 本文執行兩種實驗,第一種為動態實驗,將三隻拍翼機固定於框架上懸掛,進行水平迴旋飛行,模擬鳥類在巡航時的群體飛行,探討功率消耗是否減少。因為三隻拍翼機飛行懸掛飛行,本身並不穩定,經常造成最長滯空時間之量測中斷,故實驗所得的有限功耗數據缺乏一致性,而暫告實驗失敗。 第二種為靜態實驗,改用淡江大學風工程中心的大型風洞,進行拍翼機編隊之氣動力量測。本文製作了可移動式拍翼機群夾具,量測 1~3隻拍翼機,在不同前後距離、不同風速、不同攻角條件下的升力與推力變化,進而探討是否有達到節能的效果。實驗數據雖然複雜,但初步分析已有節能效果在風速3m/s、攻角10˚效果最好,功率減少消耗了1.2W。比對鳥類在編隊飛行時,會自行彈性調整相位和頻率,以達最佳節能效果,為本文後續研究之未來可努力改善方向。 |
英文摘要 |
According to Lissaman and Shollenberger’s article published in Science in 1970, birds fly in formation to reduce the overall energy expenditure for flight. Thus this work adopted the same principle of flight formation to flapping micro-air-vehicles (MAVs) to save energy. Two experiments are described herein. Firstly, a rigid frame housing three flapping MAVs was made and a tethered flight of it around a fixed suspension point was performed to evaluate the cruise performance of the MAV formation and check for energy saving by monitoring the endurance against a known reference value. Due to the intrinsic instabilities of the MAVs, lack of data consistency about in power saving in formation flight concludes less promising results from the 1st experiment. In the second experiment, a jig housing three flapping MAVs was subject to a wind tunnel test at the Wind Engineering Center of Tamkang University. The aerodynamic force evaluation of the MAV formation was done. The tests were performed under different wind speeds, and angle of attacks, and the lift and thrust force produced by the MAVs was measured via a force gauge. Due to the mechanical vibrations from the jig itself and the wind tunnel structure, interpretation of the complicated lift/thrust data was processed by the help of Fast Fourier Transform. From the preliminary examination, it is found that at 3 m/s, 10˚ angle of attack, the performance was the best to save power up to 1.2W. When compared to the real birds flying in a formation, the energy saving of flapping MAVs may be further improved by replicating the dynamic adjustments of frequency, phase change and separation among neighboring MAVs, to obtain best energy-saving results in the future. |
第三語言摘要 | |
論文目次 |
論文提要 I 目錄 IV 圖目錄 VI 表目錄 XIII 符號表 XIV 第一章 仿生拍翼飛行器簡介 1 1.1 研究背景 1 1.1 拍翼飛行器研究近況 1 1.2 拍翼飛行器阻力與功率 6 1.3 拍翼飛行編隊與節能 10 1.4 研究目的 14 第二章 拍翼機群水平迴旋飛行之功率初探 17 2-1 實驗構想 18 2-2 拍翼機群之吊掛機械框架設計 19 2-3 水平迴旋之飛行功率數據分析 23 第三章拍翼機群在風洞中之測力探討 27 3-1實驗構想 27 3-2拍翼機群之風洞之夾具設計 32 3-3風洞量測訊號分析 35 3-3-1數位訊號處理(FFT) 36 3-3-2同樣實驗條件下單隻到三隻拍翼力規訊號 40 3-3-3 加上實驗變數之單隻到三隻拍翼力規訊號比較 55 3-3-4 力規數據總整理 74 第四章 結論 86 4-1本文貢獻 87 4-2未來工作 88 參考文獻 89 附錄A 定電壓控制 95 附錄B 數據訊號圖 100 (a)拍翼前後距離改變訊號圖 100 (b)不同拍翼攻角情況訊號圖 105 (c)不同風速情況下拍翼訊號圖: 112 圖1 - 1 初航者 3 圖1 - 2 Eagle II 3 圖1 - 3 第一代金探子 3 圖1 - 4 Pro-金探子 3 圖1 - 5 Aero Viroment 蜂鳥懸停拍翼微飛行器 4 圖1 - 6 雙側桿機構 4 圖1 - 7 實際飛行 4 圖1 - 8 Robobees 蒼蠅拍翼微飛行器 5 圖1 - 9 伊氏近似直線機構 6 圖1 - 10編隊飛行省力圖 11 圖1 - 11 拍翼機懸掛飛行(1)水平迴旋到左側;(2)飛到右側;紅虛線為懸掛繫繩 15 圖1 - 12風洞測試 16 圖2 - 1 編隊飛行排列 17 圖2 - 2鳥類飛行之翼尖渦流 17 圖2 - 3鳥類編隊飛行之排列距離 19 圖2 - 4編隊飛行配置 20 圖2 - 5「e-bird」編隊飛行示意圖 21 圖2 - 6飛行攻角30° 22 圖2 - 7「e-bird」重心位置 22 圖2 - 8實際製作 22 圖2 - 9拍翼機懸掛飛行:(1)水平迴旋到左側;(2)飛到右側;紅虛線為懸掛繫繩 23 圖2 - 10懸掛水平迴旋飛行情形: (a)單一飛行; (b)三編隊飛行………..24 圖3 - 1實驗量測架構 28 圖3 - 2風洞翼尖渦流量測 29 圖3 - 3三隻拍翼機量測 29 圖3 - 4 拍翼機前後位置定義 30 圖3 - 5 六軸力規 31 圖3 - 6 兩隻拍翼機 32 圖3 - 7 三隻拍翼機 32 圖3 - 8 風洞量測夾具 33 圖3 - 9夾具插件 34 圖3 - 10 3D印表機 34 圖3 - 11 FFT程式碼 36 圖3 - 12 無拍翼機之升力時變圖 38 圖3 - 13 無拍翼機之升力頻譜圖 38 圖3 - 14 無拍翼機之推力時變圖 39 圖3 - 15 無拍翼機之推力頻譜圖 39 圖3 - 16 單隻無拍翼升力時變圖 42 圖3 - 17 單隻無拍翼升力頻譜圖 42 圖3 - 18 單隻拍翼升力時變圖 43 圖3 - 19 單隻拍翼升力頻譜圖 43 圖3 - 20 兩隻無拍翼升力時變圖 44 圖3 - 21 兩隻無拍翼升力頻譜圖 44 圖3 - 22 兩隻拍翼之升力時變圖 45 圖3 - 23 兩隻拍翼之升力頻譜圖 45 圖3 - 24 三隻無拍翼升力時變圖 46 圖3 - 25 三隻無拍翼升力頻譜圖 46 圖3 - 26 三隻拍翼之升力時變圖 47 圖3 - 27 三隻拍翼之升力頻譜圖 47 圖3 - 28 單隻無拍翼推力時變圖 49 圖3 - 29 單隻無拍翼推力頻譜圖 49 圖3 - 30 單隻拍翼推力時變圖 50 圖3 - 31 單隻拍翼推力頻譜圖 50 圖3 - 32 兩隻無拍翼推力時變圖 51 圖3 - 33 兩隻無拍翼推力頻譜圖 51 圖3 - 34 兩隻拍翼推力時變圖 52 圖3 - 35 兩隻拍翼推力頻譜圖 52 圖3 - 36 三隻無拍翼推力時變圖 53 圖3 - 37 三隻無拍翼推力頻譜圖 53 圖3 - 38 三隻拍翼推力時變圖 54 圖3 - 39 三隻拍翼推力頻譜圖 54 圖3 - 40 兩隻拍翼在原點升力時變圖 56 圖3 - 41 兩隻拍翼在原點升力頻譜圖 56 圖3 - 42 兩隻拍翼移動1公分升力時變圖 57 圖3 - 43 兩隻拍翼移動1公分升力頻譜圖 57 圖3 - 44 三隻拍翼在原點升力時變圖 58 圖3 - 45 三隻拍翼在原點升力頻譜圖 58 圖3 - 46 三隻拍翼移動1公分升力時變圖 59 圖3 - 47 三隻拍翼移動1公分升力頻譜圖 59 圖3 - 48 一隻拍翼攻角10˚升力時變圖 61 圖3 - 49 一隻拍翼攻角10˚升力頻譜圖 61 圖3 - 50 一隻拍翼攻角20˚升力時變圖 62 圖3 - 51 一隻拍翼攻角20˚升力頻譜圖 62 圖3 - 52 兩隻拍翼攻角10˚升力時變圖 63 圖3 - 53 兩隻拍翼攻角10˚升力頻譜圖 63 圖3 - 54 兩隻拍翼攻角20˚升力時變圖 64 圖3 - 55 兩隻拍翼攻角20˚升力頻譜圖 64 圖3 - 56 三隻拍翼攻角10˚升力時變圖 65 圖3 - 57 三隻拍翼攻角10˚升力頻譜圖 65 圖3 - 58 三隻拍翼攻角20˚升力時變圖 66 圖3 - 59 三隻拍翼攻角20˚升力頻譜圖 66 圖3 - 60 單隻拍翼在風速2m/s升力時變圖 68 圖3 - 61 單隻拍翼在風速2m/s升力頻譜圖 68 圖3 - 62 單隻拍翼在風速3m/s升力時變圖 69 圖3 - 63 單隻拍翼在風速3m/s升力頻譜圖 69 圖3 - 64 兩隻拍翼在風速2m/s升力時變圖 70 圖3 - 65 兩隻拍翼在風速2m/s升力頻譜圖 70 圖3 - 66 兩隻拍翼在風速3m/s升力時變圖 71 圖3 - 67 兩隻拍翼在風速3m/s升力頻譜圖 71 圖3 - 68 三隻拍翼在風速2m/s升力時變圖 72 圖3 - 69 三隻拍翼在風速2m/s升力頻譜圖 72 圖3 - 70 三隻拍翼在風速3m/s升力時變圖 73 圖3 - 71 三隻拍翼在風速3m/s升力頻譜圖 73 圖3 - 72 風速2m/s;攻角10度拍翼機放置不同距離升力數據圖 74 圖3 - 73 風速2m/s;攻角20度拍翼機放置不同距離升力數據圖 75 圖3 - 74 風速2m/s;攻角30度拍翼機放置不同距離升力數據圖 75 圖3 - 75 風速3m/s;攻角10度拍翼機放置不同距離升力數據圖 76 圖3 - 76 風速3m/s;攻角20度拍翼機放置不同距離升力數據圖 76 圖3 - 77 風速3m/s;攻角30度拍翼機放置不同距離升力數據圖 77 圖3 - 78 風速4m/s;攻角10度拍翼機放置不同距離升力數據圖 77 圖3 - 79 風速4m/s;攻角20度拍翼機放置不同距離升力數據圖 78 圖3 - 80 風速4m/s;攻角30度拍翼機放置不同距離升力數據圖 78 圖3 - 81 風速2m/s;攻角10度拍翼機放置不同距離推力數據圖 79 圖3 - 82 風速2m/s;攻角20度拍翼機放置不同距離推力數據圖 80 圖3 - 83 風速2m/s;攻角30度拍翼機放置不同距離推力數據圖 80 圖3 - 84 風速3m/s;攻角10度拍翼機放置不同距離推力數據圖 81 圖3 - 85風速3m/s;攻角20度拍翼機放置不同距離推力數據圖 81 圖3 - 86 風速3m/s;攻角30度拍翼機放置不同距離推力數據圖 82 圖3 - 87 風速4m/s;攻角10度拍翼機放置不同距離推力數據圖 82 圖3 - 88 風速4m/s;攻角20度拍翼機放置不同距離推力數據圖 83 圖3 - 89 風速4m/s;攻角30度拍翼機放置不同距離推力數據圖 83 圖3 - 90 升力不同風速不同攻角比較圖 84 圖3 - 91 推力不同風速不同攻角比較圖 84 圖3 - 92 結論圖……………………………………………………..........87 圖A- 1第一腳位 95 圖A- 2第三腳位 95 圖A- 3遙控器可變電阻 96 圖A- 4定電壓實驗整體架構 97 圖A- 5遙控器可變電阻 97 圖A- 6定電壓實驗電路圖………………………………………………..98 圖B- 1 兩隻拍翼在原點推力時變圖 101 圖B- 2 兩隻拍翼在原點推力頻譜圖 101 圖B- 3 兩隻拍翼移動1公分推力時變圖 102 圖B- 4 兩隻拍翼移動1公分推力頻譜圖 102 圖B- 5 三隻拍翼在原點推力時變圖 103 圖B- 6 三隻拍翼在原點推力頻譜圖 103 圖B- 7 三隻拍翼移動一公分推力時變圖 104 圖B- 8 三隻拍翼移動一公分推力頻譜圖 104 圖B- 9 一隻拍翼攻角10˚推力時變圖 106 圖B- 10 一隻拍翼攻角10˚推力頻譜圖 106 圖B- 11 一隻拍翼攻角20˚推力時變圖 107 圖B- 12 一隻拍翼攻角20˚推力頻譜圖 107 圖B- 13 兩隻拍翼攻角10˚推力時變圖 108 圖B- 14 兩隻拍翼攻角10˚推力頻譜圖 108 圖B- 15 兩隻拍翼攻角20˚推力時變圖 109 圖B- 16 兩隻拍翼攻角20˚推力頻譜圖 109 圖B- 17 三隻拍翼攻角10˚推力時變圖 110 圖B- 18 三隻拍翼攻角10˚推力頻譜圖 110 圖B- 19 三隻拍翼攻角20˚推力時變圖 111 圖B- 20 三隻拍翼攻角20˚推力頻譜圖 111 圖B- 21 單隻拍翼在風速2m/s推力時變圖 113 圖B- 22 單隻拍翼在風速2m/s推力頻譜圖 113 圖B- 23 單隻拍翼在風速3m/s推力時變圖 114 圖B- 24 單隻拍翼在風速3m/s推力頻譜圖 114 圖B- 25 兩隻拍翼在風速2m/s推力時變圖 115 圖B- 26 兩隻拍翼在風速2m/s推力頻譜圖 115 圖B- 27 兩隻拍翼在風速3m/s推力時變圖 116 圖B- 28 兩隻拍翼在風速3m/s推力頻譜圖 116 圖B- 29 三隻拍翼在風速2m/s推力時變圖 117 圖B- 30 三隻拍翼在風速2m/s推力頻譜圖 117 圖B- 31 三隻拍翼在風速3m/s推力時變圖 118 圖B- 32 三隻拍翼在風速3m/s推力頻譜圖 118 表2 - 1 e-bird一定高度與水平迴旋速度下定電壓之計時測試: 25 表2 - 2 e-bird一定高度與水平迴旋速度下之計時測試: 26 表3 - 1 3D印表機規格 35 |
參考文獻 |
[1] 何仁揚,“拍撲式微飛行器之製作及其現地升力之量測研究”,淡江大學機械與機電工程學系碩士論文,2005年六月。 [2] 施宏明,“結合PVDF現地量測之拍撲式微飛行器製作”,淡江大學機械與機電工程學系碩士論文,2007年六月。 [3] 徐振貴,“拍翼式微飛行器之設計、製造與測試整合”,淡江大學機械與機電工程學系碩士論文,2008年六月。 [4] 高敏維,“微拍翼機可撓翼之氣動力實驗”,淡江大學機械與機電工程學系碩士論文,2008年六月。 [5] L. J. Yang, C. K. Hsu, H. C. Han, and J. M. Miao, “Light flapping micro-aerial-vehicle using electrical discharge wire cutting technique,” Journal of Aircraft, 46(6), pp. 1866-1874, 2009. [6] 高崇瑜,“應用精密模造技術於微飛行器套件組之設計與製造”,淡江大學機械與機電工程學系碩士論文,2009年六月。 [7] L. J Yang, C. Y Kao, and C. K. Huang, “Development of flapping ornithopters by precision injection molding, ” Applied Mechanics and Materials, 163, pp. 125-132, 2012. [8] 廖俊瑋,“翼展10公分之拍翼式微飛行器研製”,淡江大學機械與機電工程學系碩士論文,2009年六月。 [9] M. Keennon et al., “Tailless flapping wing propulsion and control development for the Nano Hummingbird micro air vehicle, ” Future Vertical Lift Aircraft Design Conference, Jan. 18-20, San Francisco, California, 2012. [10] 鄭杰明,“仿蜂鳥懸停機構初探”,淡江大學機械與機電工程學系碩士論文,2013年6月。 [11] Harvard Microrobotics Laboratory 歷年發表文獻網址: http:// micro.seas.harvard.edu/publications.html [12] 洪方方土銓,“仿蜂鳥懸停機構套件之設計與製造”,淡江大學機械與機電工程學系碩士論文,2014年6月。 [13] C. P. Ellington,“The novel aerodynamics of insect flight: applications to micro-air-vehicles, ”The Journal of Experimental Biology, 202, pp. 3439-3448, 1999. [14] S. Ho, H. Nasseh, N. Pornsinsirirak, Y. C. Tai and C. M. Ho, “Unsteady aerodynamic and flow control for flapping wing flyers, ” Progress in Aerospace Science, 39, pp. 635-681, 2003. [15] C. S. Lin, C. Hwu and W. B. Young, “The thrust and lift of an ornithopter’s membrane wings with simple flapping motion, ”Aerospace Science and Technology, 10, pp. 111-119, 2006. [16] L. J. Yang, C. K. Hsu, J. Y. Ho, and C. K. Feng, “Flapping wings with PVDF sensors to modify the aerodynamic forces of a micro aerial vehicle, ” Sensors and Actuators A: Physical, 139, pp. 95-103, 2007. [17] B. J. Tsai and Y. C. Fu, “Design and aerodynamic analysis of a flapping-wing micro air vehicle, ”Aerospace Science and Technology, 13, pp. 383-392, 2009. [18] U. M. Norberg, Vertebrate Flight: Mechanics, Physiology, Morphology, Ecology and Evolution, 1st ed., Springer, New York, 1990. [19] C. H. Greenewalt, “The flight of birds,” Trans. Am. Philos. Soc, 65, pp. 1-67, 1975. [20] C. J. Pennycuick, “Mechanical Constraints on the Evolution of Flight, ”Vol. 8, pp. 83-98, In Padian K. (ed.) The Origin of Birds and the Evolution of Flight, Calif. Acad. Sci., San Francisco, 1986. [21] C. J. Pennycuick, “Mechanics of Flight, ” 5, pp. 1-75, In Farner, D. S. and King, J. R. (eds.) Avian Biology, Academic Press, London New York, 1975. [22] 房柏廷,“應用合拍機制於飛行器之研製”,淡江大學機械與機電工程學系碩士論文,2009年6月。 [23] P. B. S. Lissaman and C. A. Shollenberger, “Formation flight of birds,” Science, 168, pp.1003-1005, 1970. [24] C. Wieselsberger, “Beitrag zur erklarung des winkelfluges eineger zugvogel, ” Z. Flugtechnik and Motorluftschiffahrt, 5, pp.225–229, 1914. [25] J. H. Storer, The Flight of Birds, Cranbrook Press, Bloomfield Hills, Mich., 1948. [26] T. Alerstam and G. Hogstedt, “Bird migration and reproduction in relation to habitats for survial and breeding, ” Ornis Scand, 13, pp.25-37,1982. [27] W. J. Hamilton, Animal Orientation and Navigation, ed. Storm, R. M, pp. 57-71. Oregon State Univ. Press, Corvallis, 1967. [28] E. R. Hainsworth. “Energy savings through formation flight A re-examination of the vee formation,” J. Theor. Biol. , 93, pp. 41-52, 1981. [29] W. Nachtigall, “Phase relationship in the wing beat of geese flying in V formation”, Zeitschrift für Vergleichende Physiologie, 67 (4), pp. 414-422, 1970. [30] G. R. Spedding,“Mechanics of Animal Locomotion, ”11 of Advances in Comparative and Environmental Physiology, R. M. Alexander, Ed. Springer-Verlag, London, pp. 51–111, 1992. [31] M. Berger, “Formation flight without phase relationship of wing beats, ”Journal of Ornithology, 113 (2), pp. 161-169, 1972. [32] F. R. Hainsworth, “Precision and dynamics of positioning by Canada geese in formation, ” J. Exp. Biol., 128, pp. 445–462, 1987. [33] J. P. Badgerow, “A functional analysis of formation flight in Canada Geese (Branta canadens/s),” Proc. Amer. Inst. Biol. Sci. Meeting (abstr.), 1982. [34] J. J. L. Higdon and S. Corrsin, “Induced drag of a bird flock, ” American Naturalist, 112, pp. 727–744, 1978. [35] H. Weimerskirch, J. Martin, Y. Clerquin, P. Alexandre and, S. Jiraskova, “Energy saving in flight formation—pelicans flying in a ‘V’ can glide for extended periods using the other birds’ air streams, ” Nature , 413, pp. 697–698, 2001. [36] J. P. Badgerow “An analysis of function in the formation flight of Canada geese, ” American Ornithologists Union, 105, pp. 749-755, 1988. [37] C. J. Cutts and J. R. J. Speakman, “Energy Savings in Formation Flight Of Pink-Footed Geese, ” Exp. Biol., 189, pp. 251–261, 1999. [38] D. Hummel, “Formation flight as an energy-saving mechanism,” Israel J. Zool. , 41, pp. 261-278, 1995. [39] H. Heppner, “Avian flight formations, ”Bird-Banding, 45, pp. 160-169, 1974. [40] J. B. E. O'Malley and R. M. Evans,“Structure and behavior of White Pelican formation flocks, ” Canadian J. Zool. , 60, pp. 1388-1396, 1982. [41] L. L. Gould and F. H. Heppner, “The vee formation of Canada Geese,”American Ornithologists Union, 91, pp. 494-506, 1974. [42] L. J. Yang, K. C. Hung and C. K. Feng, “On the scaling laws of flapping UAVs,”APCATS, Sun-moon Lake, Taiwan, May 23-26, 2013. [43] F. B. Hsiao, “The formational flight control for UAVs, ” Invited plenary talk of the 8th International Conference on Intelligent Unmanned Systems (ICIUS 2012), Oct. 22-24, 2012, Singapore. [44] 淡江大學風工程研究中心: http://www.wind.tku.edu.tw/index.php [45] L. J. Yang, A. F. Kuo, and C. K. Hsu, “Wing stiffness on light flapping micro aerial vehicles, ” Journal of Aircraft, 49 (2), pp. 423-431, 2012. [46] Makerbot company website, from: http://store.makerbot.com/relicator2x. [47] S. J. Portugal, T. Y. Hubel and J. Fritz, “Upwash exploitation and downwash avoidance by flap phasing in ibis formation flight,”Nature, 505, pp. 399-402, 2014. |
論文全文使用權限 |
如有問題,歡迎洽詢!
圖書館數位資訊組 (02)2621-5656 轉 2487 或 來信