系統識別號 | U0002-0308201622321300 |
---|---|
DOI | 10.6846/TKU.2016.00110 |
論文名稱(中文) | 研發沉浸式薄膜過濾系統以去除海水中之結垢物質 |
論文名稱(英文) | Design of submerged membrane filtration systems for removing the foulants from seawater |
第三語言論文名稱 | |
校院名稱 | 淡江大學 |
系所名稱(中文) | 化學工程與材料工程學系碩士班 |
系所名稱(英文) | Department of Chemical and Materials Engineering |
外國學位學校名稱 | |
外國學位學院名稱 | |
外國學位研究所名稱 | |
學年度 | 104 |
學期 | 2 |
出版年 | 105 |
研究生(中文) | 蔡雅倫 |
研究生(英文) | Ya-Lun Cai |
學號 | 604400043 |
學位類別 | 碩士 |
語言別 | 繁體中文 |
第二語言別 | |
口試日期 | 2016-07-05 |
論文頁數 | 120頁 |
口試委員 |
指導教授
-
黃國楨
委員 - 莊清榮 委員 - 鄭東文 委員 - 童國倫 |
關鍵字(中) |
沉浸式微過濾 海水淡化前處理 活性碳 吸附 |
關鍵字(英) |
desalination pretreatment coagulation dynamic microfiltration submerged microfiltration powdered activated carbon |
第三語言關鍵字 | |
學科別分類 | |
中文摘要 |
本研究以沉浸式過濾系統進行海水淡化前處理。比較不同程序對於濾速與出水品質的提升。使用0.45μm之PVDF膜與活性碳動態膜對模擬海水進行過濾,並探討加入凝聚程序對於整個系統的過濾性質與水質影響。其中活性碳動態膜的生成方法,是預過濾多孔性粉末狀活性碳(PAC),使其於0.45μm PVDF膜面上形成一定量之活性碳濾餅層,此層濾餅層即稱之為動態膜。希望藉由活性碳動態膜複合式之系統,可將海水中之有機物質及無機微粒去除,以降低逆滲透程序之薄膜結垢的發生。 實驗結果顯示,用0.45μm PVDF膜過濾模擬海水,過濾初期因粒子於膜面上累積使濾速下降快速,於過濾結束後80kPa之濾速較40kPa高30%,比較使用活性碳動態膜與0.45μm PVDF膜之膜阻力可發現,於80 kPa操作下,預過濾10分鐘生成之活性碳動態膜之阻力較0.45μm PVDF膜高133%,相較於預過濾5分鐘高13%,但厚度卻增加了50%,故選用10分鐘做為動態膜預過濾時間。本研究使用5 mg/L幾丁聚醣作為凝聚劑,並以0.45μm PVDF膜過濾,其濾速會隨透膜壓差增加而提升,於過濾時間結束時,透膜壓差80kPa與60kPa相較於40kPa時濾速可提升24%與16%。因添加凝聚劑後使模擬海水中之物質粒徑分布增加,形成結構較鬆散之濾餅層,使濾餅所造成的阻力下降,因此無論使用0.45μm PVDF膜或活性碳動態膜皆可使濾速提升。最後綜合比較出水品質(COD、DOC、濁度、腐植酸濃度)與濾速之提升可知結合使用凝聚程序結合活性碳動態膜之複合系統可使上述移除率達最大,且有效使濾速提升。相較於將活性碳懸浮於海水中,使用動態膜可大幅減少活性碳用量。而使用沉浸式過濾系統生成動態膜之時間僅為掃流系統所需時間的8%,可大幅減少動態膜預過濾時間。 |
英文摘要 |
Hybrid submergedmicrofiltration systemsforpretreatment ofseawater desalinationwere studied. The permeate flux and water quality among different operations, such as 0.45μm hydrophilic membranes, dynamic membrane formed bypowder activated carbon (PAC), dynamic membrane coupled with coagulation operationwere measured and compared.The PAC dynamic membranes, constructed bypre-coatingPAC on the primarymembrane,were used forabsordingorganic material andinorganic fine particles in seawater to prevent the membrane fouling in following Reverse Osmosis(RO) units. Artificial seawater was filtered using0.45μm PVDFmembrane, the filtration flux increased30% asthe transmembrane pressure increased from 40 to 80kPa. However,the flux decayed more quickly under higher pressures.The membrane resistance of the PAC dynamic membrane was133%higherthan that of 0.45μm PVDF membraneunder 80 kPa.ThePACthicknessincreased 50% with twice coating time. However the resistanceonly increased 13%. It was attributed to the large PAC particle size and loose packing structure of dynamic membrane. Tocombine coagulationoperations withsubmergedfiltration processes, either theuseof 0.45μm PVDFmembrane or PAC dynamic membrane, the flux was improved.The flux of seawaterwithcoagulant increased with increasing transmembranepressure.However, theflux declineddramatically at the beginning of filtration, the major resistance sources werethose organic materials fouling on themembranes.Comparing the performances of different operations, the hybrid system coupled with coagulation and PAC dynamic membrane behaved the highest efficiency of pollutant removal and highest permeate flux.The quality of permeate water, COD,DOC,turbidityand concentration of humic acid, for each operation was measured.The permeate quality met the requirement of RO feed.On the other hand,compared to directly add PAC into suspensionto adsorb organic material, the use of PAC dynamic membrane significantly reduce the cost of PAC.Beside, the submerged system only cost 8% of pre-coating time by cross-flow system. |
第三語言摘要 | |
論文目次 |
中文摘要 I 英文摘要 II 目 錄 IV 圖目錄 VIII 表目錄 XI 第一章 緒論 1 1-1薄膜分離程序 1 1-2海水淡化技術 4 1-3研究動機與目的 7 第二章 文獻回顧 9 2-1活性碳吸附 9 2-1-1活性碳之吸附原理 10 2-1-3活性碳之種類及操作型態 12 2-2動態膜之機制與性質 12 2-3化學混凝原理 13 2-3-1混凝之機制 13 2-3-2影響混凝之因素 17 2-4薄膜生物反應器 19 2-4-1薄膜生物反應器特性 20 2-4-2薄膜生物反應器種類 22 2-4-3 SMBR中結垢的性質 24 2-5薄膜過濾前處理 26 第三章 理論 31 3-1阻力串聯模式 31 3-2濾餅性質 32 3-3粒子力平衡方程式 33 第四章 實驗裝置與方法 39 4-1沉浸式過濾實驗裝置 39 4-2實驗材料 41 4-2-1實驗藥品 41 4-2-2實驗濾膜 44 4-3分析儀器 45 4-4實驗流程 47 4-4-1粉末狀活性碳(Powder activated carbon,PAC)懸浮液配置 47 4-4-2模擬海水配置 47 4-4-3實驗步驟 51 4-4-4出水品質之分析方法 54 第五章 結果與討論 57 5-1模擬海水沉浸式微過濾性質 57 5-1-1模擬海水之沉浸式過濾濾速 57 5-1-2濾餅性質及阻力分析 60 5-1-3出水品質分析 66 5-2結合活性碳動態膜之沉浸式過濾系統 68 5-2-1粉末狀活性碳厚度分析 68 5-2-2粉末狀活性碳之沉浸式微過濾 72 5-2-3使用活性碳動態膜於不同壓差對濾速之影響 75 5-2-4使用活性碳動態膜於不同壓差對濾餅性質之影響 77 5-2-5使用活性碳動態膜於不同壓差對出水品質之影響 79 5-3結合凝聚之沉浸式過濾系統 80 5-3-1幾丁聚醣之杯瓶試驗 80 5-3-2使用凝聚劑於模擬海水於不同壓差對濾速之影響 83 5-3-3使用凝聚劑於模擬海水於不同壓差對濾餅性質之影響 85 5-3-4使用凝聚劑於模擬海水於不同壓差對出水品質之影響 88 5-4使用凝聚程序結合PAC動態膜之沉浸式過濾系統 89 5-4-1結合凝聚與PAC動態膜於不同壓差對濾速之影響 89 5-4-2結合凝聚與PAC動態膜於不同壓差對濾餅性質之影響 92 5-4-3結合凝聚與PAC動態膜於不同壓差對出水品質之影響 94 5-5模擬海水於不同操作程序下之比較 95 5-5-1對於濾速與濾餅性質之影響 95 5-5-2不同操作程序下之出水品質 101 5-5-3活性碳動態膜長時間操作之影響 103 5-5-4與過去文獻比較 108 第六章 結論 112 符號說明 116 Greek letters 117 參考文獻 118 圖目錄 頁次 Fig. 1-1 Range of molecular weights and particle or droplet sizes of common materials, how they are measured, and the methods employed for their removal from fluids. (Osmonics Inc.) (Walas, 2012). 3 Fig2-1 溶質在活性碳表面擴散吸附路徑 11 Fig2-2 Pathways for the removal of NOM by aluminium-based coagulation(Gregor,Nokes and Fenton,1997) 16 Fig.2-3 Pretreatment options for SWRO. (Monnot, 2016). 21 Fig.2-4 Kind of solid-liquid separation mode of MBR :( a ) side-stream or external MBR; (b ) submerged MBR, SMBR 23 Fig.2-5 Effect the main membrane fouling factor. 26 Fig.2-1 Forces exerted on a depositing particle in a submerged micro-filtration 35 Fig.2-2 Interaction energy of Van der Walls force and electrical double layer repulsive force under different distance. 37 Fig.4-3 The microphotograph of artificial seawater with 3600 times. (a)only add Humic acid (b)add both Humic acid and SiO2. 50 Fig.4-4 Size distribution in artificial seawater. 50 Fig.4-4 The absorbance vs. concentration of humic acid solution. 54 Fig.5-1 Time courses of filtration flux during submerged microfiltration with ceramic membrane under various transmembrane pressures. 59 Fig.5-2 Time courses of filtration flux during submerged microfiltration with flat sheet membrane under various transmembrane pressures. 60 Fig.5-3 Time courses of filtration flux during submerged microfiltration under various transmembrane pressures. 60 Fig.5-4 Filtration resistances in submerged microfiltration of artificial seawater with ceramic membrane under various transmembrane pressures. 63 Fig.5-5 Filtration resistances in submerged microfiltration of artificial seawater with flat sheet membrane under various transmembrane pressures. 64 Fig.5-6 Effect of cake mass and average specific filtration resistance under various transmembrane pressure. 65 Fig.5-7 Effect of cake mass and average specific filtration resistance under various transmembrane pressure. 65 Fig.5-8 Comparison of HA concentration and turbidity of filtrate under various transmembrane pressures. 67 Fig.5-9 Comparison of COD and DOC of filtrate under various transmembrane pressures. 67 Fig.5-10 The photo of PAC dynamic membrane. (a)thickness of 0.2 cm of PAC (b)thickness of 0.5 cm of PAC 69 Fig.5-11 Analysis of coating 5 min of power activated carbon for thickness under various operating conditions. 71 Fig.5-12 Time course of filtration flux during submerged microfiltration under various transmembrane pressure. 72 Fig.5-13 Resistances in submerged microfiltration under various transmembrane pressures. 74 Fig.5-14 Time courses of filtration flux during submerged microfiltration of artificial seawater under various transmembrane pressures. 76 Fig.5-15 Filtration resistances in submerged microfiltration of artificial seawater under various transmembrane pressures (after operating 2 hrs). 78 Fig.5-17 Comparison of COD and DOC of filtrate under various transmembrane pressures. 80 Fig.5-18 Floc sizes distribution of artificial seawater under various dose of chitosan. 82 Fig.5-19 Mean floc diameter and supernatant turbidity under various dose of chitosan. 83 Fig. 5-20 Time courses of filtration flux during submerged microfiltration of artificial seawater under various transmembrane pressures. 84 Fig.5-21 Resistances of using coagulation process in submerged microfiltration under different transmembrane pressures. 85 Fig.5-22 Effect of cake mass and average specific filtration resistance under various filtration pressures under various transmembrane pressures. 86 Fig.5-23 Floc sizes distribution of artificial seawater at submerged microfiltration. 87 Fig.5-24 Comparison of HA concentration and turbidity of filtrate under various transmembrane pressures. 88 Fig.5-25 Comparison of COD and DOC of filtrate under various transmembrane pressures. 89 Fig.5-26 Time courses of filtration flux during combine with coagulation process and PAC dynamic membrane in cross-flow microfiltration under various transmembrane pressures. 91 Fig.5-27 The photo of filitration cake with coagulation process and PAC dynamic membrane in submerged microfiltration 91 Fig.5-28 Resistances of combine with coagulation process and PAC dynamic membrane in submerged microfiltration under different transmembrane pressures. 92 Fig.5-29 Effect of cake mass and average specific filtration resistance in this process under various transmembrane pressures . 93 Table.5-3 Comparison of HA concentration and turbidity of filtrate under 94 Fig.5-30 Comparison of COD and DOC of filtrate under various transmembrane pressures. 95 Fig.5-31 Time courses of filtration flux during different process in submerged microfiltration under transmembrane pressure 80kPa. 96 Fig.5-32 Pseudo steady filtration flux ime during different process in submerged microfiltration under different transmembrane pressure 98 Fig.5-33 Resistances during different process in submerged microfiltration under transmembrane pressure 80kPa. 100 Fig.5-34 Effect of cake mass and average specific filtration resistance during different process in submerged microfiltration under transmembrane pressure 80kPa. 100 Table.5-4 Comparison of HA concentration and turbidity of filtrate under various process. 102 Fig.5-35 Comparison of COD and DOC of filtrate under various process. 102 Fig.5-37 Time course of filtration flux during submerged microfiltration. 104 Fig.5-38 The microphotograph of particle from filitration cake with 900 times. 105 Fig.5-39 The photo of filitration cake with coagulation process and PAC dynamic membrane in submerged microfiltration( after operating 27 hrs). 106 Fig.5-40 Floc sizes distribution of artificial seawater at submerged microfiltration. 106 表目錄 頁次 Table3-1 The average specific filtration resistance and permeability 32 Table 4-1 Characteristics of powdered activated carbon used in this study.( Hwang ,2014) 47 Table 4-2 Composition of artificial seawater 48 Table 4-3 Properties of artificial seawater 48 Table 4-3 The operating condition used in this study. 52 Table.5-1 Analysis of power activated carbon for thickness under various operating conditions. 69 Table.5-2 Comparison of HA concentration and turbidity of filtrate under various transmembrane pressures. 79 Table.5-3 Comparison of HA concentration and turbidity of filtrate under various transmembrane pressures. 94 Table 5-5 Resistances, cake mass and average specific filtration resistance from using coagulation process and PAC dynamic membrane in submerged microfiltration. 107 Table 5-6 Analysis of permeate quality from using coagulation process and PAC dynamic membrane in submerged microfiltration. 108 Table5-7 Comparison of the removal efficiency of DOC with recent studies. 110 Table5-8 Comparison of flux with recent studies. 110 Table5-9 Comparison of the operation condition for generate PAC dtnamic membrane with recent studies. 111 |
參考文獻 |
Gregor, J.E., Nokes, C.J., and Fenton, E. “Optimising natural organic matter removal from low turbidity waters by controlled pH adjustment of aluminium coagulation”, Water Research, 31 (12), 2949-2958(1997). Hu, C.-Y., Lo, S.-L., Chang, C.-L., Chen, F.-L., Wu, Y.-D., and Ma, J.-L. “Treatment of highly turbid water using chitosan and aluminum salts”, Sep. Purif. Technol., 104, 322-326(2013). James R. Couper,W. Roy Penney,James R. Fair, PhD, “Chemical Process Equipment: Selection and Design, Third Edition”, USA, Chap.19, 677–678 (2012). Jeong, S., Choi, Y.J., Nguyen, T.V., Vigneswaran, S., and Hwang, T.M., “Submerged membrane hybrid systems as pretreatment in seawater reverse osmosis (SWRO): Optimisation and fouling mechanism determination”, Journal of Membrane Science, 411-412, 173-181 (2012) Jeong, S., Naidu, G., and Vigneswaran, S. “Submerged membrane adsorption bioreactor as a pretreatment in seawater desalination for biofouling control” , Bioresour. Technol, 141, 57-64(2013). Jeong, S., Rice, S.A., and Vigneswaran, S. “Long-term effect on membrane fouling in a new membrane bioreactor as a pretreatment to seawater desalination” , Bioresour. Technol, 165 (C), 60-68(2014). Jeong, S., and Vigneswaran, S., “Practical use of standard pore blocking index as an indicator of biofouling potential in seawater desalination”, Desalination, 365, 8-14 (2015) Jeong, S., Vollprecht, R., Cho, K., Leiknes, T., Vigneswaran, S., Bae, H., and Lee, S., “Advanced organic and biological analysis of dual media filtration used as a pretreatment in a full-scale seawater desalination plant”, Desalination, 385, 83–92 (2016) Jeong, S., Cho, K., Bae, H., Keshvardoust, P., Rice, S.A., Vigneswaran, S., Lee, S., and Leiknes T., “Effect of microbial community structure on organic removal and biofouling in membrane adsorption bioreactor used in seawater pretreatment”, Chemical Engineering Journal, 294, 30-39 (2016) Ma, W., Y. Zhao and L. Wang, “The pretreatment with enhanced coagulation and a UF membrane for seawater desalination with reverse osmosis”, Desalination, 203, 256–259 (2007). Md, M., Khan, T., Takizawa, S., Lewandowski, Z., Jones, W.L., Camper, A.K., Katayama, H., Kurisu, F., and Ohgaki,S. “Membrane fouling due to dynamic particle size changes in the aerated hybrid PAC–MF system”, J. Membr. Sci, 371, 99-107(2011). Monnot, M., Laborie, S., and Cabassud, C. “Granular activated carbon filtration plus ultrafiltration as a pretreatment to seawater desalination lines: Impact on water quality and UF fouling” , Desalination, 383, 1-11. (2016) Nguyen, T.V., Jeong, S., Pham, T.T.N., Kandasamy, J., and Vigneswaran, S. “Effect of granular activated carbon filter on the subsequent flocculation in seawater treatment”, Desalination, 354, 9-16(2014). Pramanik, B.K., Roddick, F.A. , Fan, L., Jeong, S., and Vigneswaran, S., “Assessment of biological activated carbon treatment to control membrane fouling in reverse osmosis of secondary effluent for reuse in irrigation”, Desalination, 364, 90–95 (2015) Shin, H. S., S. M. Lee, I. S. Seo, G. O. Kim, K. H. Lim and J. S. Song, “Nitrogen Compounds from Greywater.”, Water Sciences and Technology, 38, 79, (1998) Zhao, Y.X., Gao, B.Y., Shon, H.K., Kim, J.-H., Yue, Q.Y., and Wang, Y. “Floc characteristics of titanium tetrachloride (TiCl4) compared with aluminum and iron salts in humic acid-kaolin synthetic water treatment” , Sep. Purif. Technol., 81 (3), 332-338. (2011) Zhang, Q., Xu, R., Xu, P., Chen, P. , He, Q., Zhong, J., and Gu, X., “Performance study of ZrO2 ceramic micro-filtration membranes used in pretreatment of DMF wastewater”, Desalination, 346, 1-8 (2014) 楊萬發譯,“水及廢水處理化學”,國立編譯館主編、茂昌圖書有限公司發行,第六章、第七章(1987)。 鄭喬維 編著,結合凝聚程序與活性碳動態膜於掃流微過濾以應用於海水淡化前處理,碩士學位論文,淡江大學化材系,台北,台灣(2015). |
論文全文使用權限 |
如有問題,歡迎洽詢!
圖書館數位資訊組 (02)2621-5656 轉 2487 或 來信